Men 4XL (chest 121 cm)

Blazer pattern, men's size 4XL (121 cm chest)

Two-button sport coat with patch pockets.

17pattern pieces

37pieces to cut

≈ 2.75 ydof main fabric (60" wide)

You will also need: lining, tailoring canvas, specialty fabric.

Sewing instructions

General steps to sew this garment. Seam allowance is 1 cm (3/8") unless stated otherwise.

Print the pattern at 100%, check the test square and cut the pieces following the cutting list. Transfer notches, darts and button marks.
Interface the facings, collar, pocket openings and front as marked.
Sew the darts from the edge to the point, tie off without backstitching and press them toward the center.
Prepare the patch pockets (hem the top, press the edges under) and topstitch them in place.
Assemble the shell: back, side and shoulder seams; press each seam as you go.
Sew the two-piece sleeve (top and under sleeve) and set it into the armhole, easing the cap.
Join collar and undercollar, turn and attach them to the neckline together with the facings.
Assemble the lining like the shell, attach it to the facings and bag it at the hem, leaving an opening to turn.
Mark and sew the buttonholes, then sew on the buttons opposite them.

Measurement	Value	How to measure
Biceps circumference	42.4 cm	Around the widest part of the relaxed upper arm.
Chest/bust circumference	121.1 cm	Around the torso at the fullest part of the chest, tape level.
Shoulder to bust	31.8 cm	From the high point of the shoulder (next to the neck) to the bust point.
Back length	53.4 cm	From the high shoulder point, down the back, to the waist.
Neck circumference	46 cm	Around the base of the neck, where a shirt collar sits.
Shoulder width	51.2 cm	From one shoulder point to the other, across the back.
Shoulder slope	13°	Shoulder angle in degrees (usually between 10 and 15).
Waist to armpit	23.9 cm	Vertically along the side, from the waist to the armpit.
Waist to hips	14.8 cm	Along the side, from the waist to the hip line.
Hip circumference	101.7 cm	Around the hips, at the level of the hip bones.
Waist circumference	95.5 cm	Around your natural waist, the narrowest part of the torso.
Shoulder to elbow	39.8 cm	From the shoulder point to the elbow, arm slightly bent.
Arm length	67 cm	From the shoulder point to the wrist, arm slightly bent.
Wrist circumference	19.3 cm	Around the wrist, over the bone.

Standard sizes are a starting point. Enter your own measurements in the editor and the pattern is redrafted for your body in seconds, for free.